We have the best radiant heated systems available. Try us and you'll be convinced!

Our products are time-tested. 

 

© tempurtech

DESIGN CONSIDERATIONS

​   ​ROLL OF HEATED MATS              UNROLL MATS              APPLY ADHESIVE         ROLL OUT MATS

SELF REGULATING ELECTRIC CABLE SYSTEM

​The self regulating heating cables are a nightmare to install ,not to mention the potential for roof damage . This is an expensive system to purchase and expensive to install and is not very energy efficient. The major failure rate is due to the wires either short or burn out. This is the worst system you could ever purchase.

CUSTOM HEATED SCUPPER AND DRAIN MATS.

The major problems with a large commercial roof is that when the snow and ice melts the water tends to refreeze and ice dams form that prevent the water from draining off the roof and this creates excessive weight loads on the roof. Depending on the type of roof , Tempurtech can design mats to fit around the scuppers or drain to prevent freezing.

SNOW LOAD ON CANOPY

            

            COMMERCIAL   HEATED    ROOfs          

      

HEATED DRIP EDGE MATS

Tempurtech manufactures heated drip edge mats that maybe applied under new roof install or placed on top of an existing roof . The mats are 5 inch , 12 inch or 24 inches wide and up to 150 feet long depending on the width. The mats are pre made per installation and require very little effort to install. All necessary electrical and cord placements are designed per electricians request .The mats are available in 110v or 220v. 

​               

Tempurtechs line of commercial  heated flat roof  mats prevent ice and snow loads from creating damage to large surfaces.

Tempurtechs advanced carbon nano emulsion patented heating element is designed not to burn out and be the most energy efficient way to melt ice and snow on large surfaces. Tempurtech is the only company in the U.S.A. that can manufacture large heated mats up to 100 feet long.  When supplied with architectural drawings Tempurtech can design , engineer and produce a custom heated roofing system that is easy to install, energy efficient and very effective in melting ice and snow. The most common widths are 5 inches ,12 inches ,24 inches and 4 feet up to 100 feet long and available in 110v  .14  amps per sq. ft or 220v 1 ph .09 amps sq. ft. All the mats maybe manufactured in TPO , PVC , EPDM  or PTE and are designed for easy installation.




      In designing heated roof systems we have to consider           many different factors that determine the best solution.

  • ROOF TYPE ; flat , pitched ,residential ,commercial
  • ROOF MATERIAL : EPDM , TPO ,PVC. SHINGLES
  • DRAINAGE : Gutters , Leaders ,Valleys .
  • INSTALLATION : Best way and easiest
  • AVAILABLE ELECTRICAL SERVICE
  • NEW ROOF OR EXISTING
  • SAFE GUARD THE ROOF INTEGRITY AND WARRANTY

CUSTOM DESIGNED                       FINISHED MATS             

COMMERCIAL HEATED  DRAIN MATS

The most important factor in melting ice and snow off a commercial roof is to make sure the water can drain off the roof  before it refreezes again. After 9 years of manufacturing heated roof mats ,Tempurtech has developed a heated mat with a built in drain screen on  the bottom of the mat to allow water to flow under the mat over to the scuppers .

SOLVED USING 2- 320 FOOT HOT MATS .

HYDRONIC SYSTEM

This system requires extensive labor to install , constant maintaince ,extensive equipment repairs ,relays , piping ,manifolds ,control valves and heating system. This system cannot be shut off unless system is filled with anti freeze or pipes will burst and it has a slow recovery time . This is the most expensive system to purchase .

COMPARISON TO OTHER HEATED ROOF SYSTEMS

COMMERCIAL / INDUSTRIAL HEATED ROOF MATS

​​LOAD 6 FEET HIGH       320 FEET LONG .

 SOLVED USING HEATED MAT WITH DRAIN


Tempurtechs heated commercial roof mats offer a safer and more energy efficient system for melting ice and snow build up on roofs. Utilizing our patented carbon sheet heating element , we can manufacture large mats that are easy to install and cover large areas. These mats are very easy to install , which saves on installation cost , provide more heat per square foot , most energy efficient system available , no internal wires , maybe walked on and cost less than any other form of heated roof system.

HEATED MATS

​​TEMPURTECH HEATED ROOF MATS , ARE THE ONLY PRODUCTS AVAILABLE THAT CAN MELT EXCESSIVE  ROOF SNOW LOADS THAT COVER LARGE AREAS.